CLC number: TN433
On-line Access: 2022-02-28
Received: 2020-08-11
Revision Accepted: 2022-04-22
Crosschecked: 2021-01-18
Cited: 0
Clicked: 5535
Citations: Bibtex RefMan EndNote GB/T7714
Sheng LIU, Menglian ZHAO, Zhao YANG, Haonan WU, Xiaobo WU. A large-current, highly integrated switched-capacitor divider with a dual-branch interleaved topology and light load efficiency improvement[J]. Frontiers of Information Technology & Electronic Engineering,in press.https://doi.org/10.1631/FITEE.2000404 @article{title="A large-current, highly integrated switched-capacitor divider with a dual-branch interleaved topology and light load efficiency improvement", %0 Journal Article TY - JOUR
具有双支路交错拓扑结构和轻载效率优化模式的大电流、高集成度开关电容分压器1浙江大学电气工程学院,中国杭州市,310027 2浙江大学信息与电子工程学院,中国杭州市,310027 摘要:由于无磁且容易实现高集成度,开关电容(SC)变换器作为一种直流变压器在现代电子领域具有广泛应用前景。然而,设计具有大电流和高功率的SC变换器仍面临挑战。本文提出一种双支路SC分压器拓扑,并通过集成电路(IC)得以实现。所设计SC变换器能驱动大电流负载,将其使用范围扩展至大功率应用场合。该SC变换器具有1/2的恒定变换比,其双支路交错操作方式可确保输入电流的连续性。此外,提出一种使用电容耦合型浮动电压电平转换器的片上栅极驱动方法有效驱动全NMOS功率链。通过自供电结构,飞电容器本身也是用于栅极驱动的自举电容器,从而减少所需元器件数量。采用数字调制方式,在轻载时自动降低开关频率以提高效率。所设计SC变换器IC使用180 nm三阱BCD工艺制造。实验结果证明了所提双支路交错操作方式和自供电栅极驱动方法的有效性。所设计SC变换器可在5至12V的输入电压下驱动高达4A的负载电流,功率效率高达96.5%。在轻负载条件下,使用所提优化方法,电源效率提高了30%。 关键词组: Darkslateblue:Affiliate; Royal Blue:Author; Turquoise:Article
Reference[1]Andersen TM, Krismer F, Kolar JW, et al., 2017. A 10 W on-chip switched capacitor voltage regulator with feedforward regulation capability for granular microprocessor power delivery. IEEE Trans Power Electron, 32(1):378-393. doi: 10.1109/TPEL.2016.2530745 [2]DA9318, 2017. DA9318 Direct Charging Reference Board. Germany: Dialog Semiconductor. https://www.manualslib.com/manual/1634181/Dialog-Da9318.html [3]Fardahar SM, Sabahi M, 2020. New expandable switched-capacitor/switched-inductor high-voltage conversion ratio bidirectional DC-DC converter. IEEE Trans Power Electron, 35(3):2480-2487. doi: 10.1109/TPEL.2019.2932325 [4]Fei C, Ahmed MH, Lee FC, et al., 2017. Two-stage 48 V–12 V/6 V–1.8 V voltage regulator module with dynamic bus voltage control for light-load efficiency improvement. IEEE Trans Power Electron, 32(7):5628-5636. doi: 10.1109/TPEL.2016.2605579 [5]Jawalikar P, Patle N, Sahoo BD, 2020. Time-domain modeling and analysis of switched-capacitor converters. IEEE Trans Power Electron, 35(8):8276-8286. doi: 10.1109/TPEL.2020.2964263 [6]Jong O, 2019. Multi Resonant Switched-Capacitor Converters. MS Thesis, Virginia Polytechnic Institute and State University, Blacksburg, USA. [7]Lehmann T, 2014. Design of fast low-power floating high-voltage level-shifters. Electron Lett, 50(3):202-204. doi: 10.1049/el.2013.2270 [8]Liu WL, Wang Z, Wang G, et al., 2020. Switched-capacitor-convertors based on fractal design for output power management of triboelectric nanogenerator. Nat Commun, 11(1):1883. doi: 10.1038/s41467-020-15373-y [9]Liu ZD, Cong L, Lee H, 2015. Design of on-chip gate drivers with power-efficient high-speed level shifting and dynamic timing control for high-voltage synchronous switching power converters. IEEE J Sol-State Circ, 50(6):1463-1477. doi: 10.1109/JSSC.2015.2422075 [10]Luo ZC, Ker MD, Cheng WH, et al., 2017. Regulated charge pump with new clocking scheme for smoothing the charging current in low voltage CMOS process. IEEE Trans Circ Syst I Reg Pap, 64(3):528-536. doi: 10.1109/TCSI.2016.2619693 [11]Meyvaert H, Piqué GV, Karadi R, et al., 2015. 20.1 A light-load-efficient 11/1 switched-capacitor DC-DC converter with 94.7% efficiency while delivering 100 mW at 3.3V. Proc IEEE Int Solid-State Circuits Conf, p.1-3. doi: 10.1109/ISSCC.2015.7063074 [12]Moghe Y, Lehmann T, Piessens T, 2011. Nanosecond delay floating high voltage level shifters in a 0.35 μm HV-CMOS technology. IEEE J Sol-State Circ, 46(2):485-497. doi: 10.1109/JSSC.2010.2091322 [13]Mostacciuolo E, Vasca F, Baccari S, 2018. Differential algebraic equations and averaged models for switched capacitor converters with state jumps. IEEE Trans Power Electron, 33(4):3472-3483. doi: 10.1109/TPEL.2017.2702389 [14]Palumbo G, Pappalardo D, 2010. Charge pump circuits: an overview on design strategies and topologies. IEEE Circ Syst Mag, 10(1):31-45. doi: 10.1109/MCAS.2009.935695 [15]Sanders SR, Alon E, Le HP, et al., 2013. The road to fully integrated DC-DC conversion via the switched-capacitor approach. IEEE Trans Power Electron, 28(9):4146-4155. doi: 10.1109/TPEL.2012.2235084 [16]Schaef C, Stauth JT, 2018. A highly integrated series—parallel switched-capacitor converter with 12 V input and quasi-resonant voltage-mode regulation. IEEE J Emerg Sel Top Power Electron, 6(2):456-464. doi: 10.1109/JESTPE.2017.2762083 [17]Schaef C, Rentmeister J, Stauth JT, 2018. Multimode operation of resonant and hybrid switched-capacitor topologies. IEEE Trans Power Electron, 33(12):10512-10523. doi: 10.1109/TPEL.2018.2806927 [18]Seeman MD, Sanders SR, 2008. Analysis and optimization of switched-capacitor DC–DC converters. IEEE Trans Power Electron, 23(2):841-851. doi: 10.1109/TPEL.2007.915182 [19]Souvignet T, Allard B, Lin-Shi X, 2015. Sampled-data modeling of switched-capacitor voltage regulator with frequency-modulation control. IEEE Trans Circ Syst I Reg Pap, 62(4):957-966. doi: 10.1109/TCSI.2015.2399025 [20]Xu M, Sun J, Lee FC, 2006. Voltage divider and its application in the two-stage power architecture. Proc Twenty-First Annual IEEE Applied Power Electronics Conf and Exposition, Article 7. doi: 10.1109/APEC.2006.1620584 [21]Yuan B, Ying J, Ng WT, et al., 2020. A high-voltage DC–DC buck converter with dynamic level shifter for bootstrapped high-side gate driver and diode emulator. IEEE Trans Power Electron, 35(7):7295-7304. doi: 10.1109/TPEL.2019.2955310 [22]Zhang F, Du L, Peng FZ, et al., 2008. A new design method for high-power high-efficiency switched-capacitor DC–DC converters. IEEE Trans Power Electron, 23(2):832-840. doi: 10.1109/TPEL.2007.915043 Journal of Zhejiang University-SCIENCE, 38 Zheda Road, Hangzhou
310027, China
Tel: +86-571-87952783; E-mail: cjzhang@zju.edu.cn Copyright © 2000 - 2024 Journal of Zhejiang University-SCIENCE |
Open peer comments: Debate/Discuss/Question/Opinion
<1>